Product ID:NOX RUST 509
MSDS Date:02/01/1993
FSC:8030
NIIN:00-231-2353
MSDS Number: BTTGC

DAUBERT CHEMICAL COMPANY

4700 S CENTRAL AVE
CHICAGO, IL 60638
US

Emergency Phone: 312-496-7350/800-424-9300(CHEMTREC)

Info Phone: 312-496-7350/FAX 708-496-7367

Preparer: J KUKSUK

Cage: 7X108

RALRUBE INC.

FARMINGTON HILLS, MI 48331 US

Telephone: 248-661-0260, FAX 248-661-3941

Cage: 6X798

64741-96-4 &/OR 64742-52-5;

Fraction By Weight: 70-75%

OSHA PEL 5 MG/CUM AS OIL MIST

ACGIH TLV: 5 MG/CUM AS OIL MIST

PETROLEUM HYDROCARBON (PETROLATUM).

CAS: 8009-03-8

Fraction By Weight: 13-18%

OSHA PEL 2MG/M3 (MFG'S)

ACGIH TLV: 2MG/M3 FUMES (MFG'S)

PARAFFIN WAX

CAS: 8002-74-2

RTECS: RV0350000

Fraction By Weight: 3-6%

OSHA PEL 2 MG/M3 (FUME)

ACGIH TLV: 2 MG/M3 (FUME); 9394

VOLATILE ORGANIC COMPOUNDS, UNITS IN LBS/LITER.

RTECS: 9999999VO

Fraction By Weight: <0.4%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EXCESSIVE INHAL MAY PRODUCE
DIZZINESS, NAUSEA, HEADACHE, & UNCOORDINATION. MAY CAUSE REVERSIBLE
EYE & SKIN IRRIT. PROLONGED SKIN EXPOSURE MAY CAUSE DERM OR OIL
ACNE. BREATHING MISTS MAY CAUSE D IZZINESS OR PULMONARY IRRIT.
CHRONIC EFFECTS NOT DETERMINED.
Explanation of Carcinogenicity:PER MSDS NONE OF THE COMPONENTS OF THIS
PRODUCT ARE LISTED AS CARCINOGENS BY NTP, IARC, OR OSHA 1910(Z).
Effects of Overexposure:DIZZINESS, NAUSEA, HEADACHE, UNCOORDINATION.
REVERSIBLE EYE/SKIN IRRIT. DERM OR OIL ACNE. PULM IRRIT.
Medical Cond Aggravated by Exposure:EXPOSURE MAY AGGRAVATE PRE-EXISTING
RESPIRATORY OR SKIN PROBLEMS.

First Aid:INHAL:REMOVE TO FRESH AIR. CONSULT PHYSICIAN. IF BREATH DIFFI
GIVE OXYGEN. NOT BREATH,GIVE ARTI RESP. EYES:FLUSH EYES IMMED
W/RUNNING WATER @ LEAST 15MINS. SEEK MED ATTN IMMED. SKIN:WASH
W/SOAP & WATE R. REMOVE CONTAMIN CLOTH/SHOE @ SITE. INGEST:DO NOT
INDUCE VOMITING. CONSULT PHYSICIAN. IF VOMITING OCCURS
SPONTANEOUSLYU KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUID
INTO LUNGS.

Flash Point Method:COC
Flash Point:>300F,>149C
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY, OR
REGULAR FOAM.
Fire Fighting Procedures:WEAR + PRESSURE SCBA & PROTECTIVE
CLOTHING.COOL CNTNRS EXPOSED TO FLAMES W/WATER SPRAY.STAY
UPWIND.KEEP OUT OF LOW AREAS.TANK,RAILCAR,TRUCK ON FIRE ISOLATE
.5MI
Unusual Fire/Explosion Hazard:VAPORS MAY TRAVEL TO IGN SOURCE &
FLASHBACK.CNTNR MAY EXPLODE IN HEAT/FIRE.VAPOR EXPLOSION HAZ
INDOORS/OUTDOORS/SEWERS.

Spill Release Procedures:SHUT OFF IGNITION SOURCES;NO
FLARES,SMOKING,FLAMES IN HAZ AREA. STOP LEAK W/O RISK. LG
SPILLS:DIKE FAR AHEAD OF LIQ SPILL FOR LATER DISPOSAL. SM
SPILLS:TAKE UP W/SAND OR OTHER NONCOMBUSTIBLE ABSORBENT MATL &
PLACE INTO CONTAINERS FOR LATERDISPOSAL.

Handling and Storage Precautions:STORE IN COOL,WELL-VENT AREA.KEEP AWAY
FROM FLAME,SPARK,HOT SURFACES.NEVER USE TORCH TO CUT/WELD ON/NEAR
CNTNR.EMPTY CNTNRS CAN CONTAIN EXPLOSIVE VAPO
Other Precautions:NEVER WEAR OIL SOAKED CLOTHING.LAUNDER/DRY CLEAN
BEFORE WEARING.DISCARD OIL SOAKED SHOES.WASH WELL W/SOAP & WATER
(WATERLESS HAND CLEANSER MAY BE HELPFUL IN REMOVING RESIDUE) AFT
USE & BEFORE SMOKING OR EATING.AVOID EXCESSIVE SKIN CONTACT.

Respiratory Protection:NIOSH APPROVED RESPIRATOR FOR ORGANIC VAPOR AND
MIST TO CONTROL EXPOUSRE WHERE VENTILATION IS INADEQUATE.
Ventilation:GENERAL AND LOCAL EXHAUST.
Protective Gloves:IMPERVIOUS (VITON, PVOH, ETC).
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS,CHEM GOGGL
Other Protective Equipment:IF SPLASHING IS ANTICIPATED, WEAR RUBBER
APRON & BOOTS OR OTHER PROTECTIVE EQPMT TO MINIMIZE CONTACT.
Work Hygienic Practices:PRACTICE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
FIRE:STAY AWAY FROM ENDS OF TANKS. USE UNMANNED HOSE HOLDER/MONITOR NOZ
FOR MASSIVE FIRE IN CARGO AREA. WITHDRAW IMMED IF RISING SOUND FROM
VENTING SAFETY DEVICE OR DISCOLORATION OF TANK.

HCC:N1
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:<1
Vapor Density:>1
Spec Gravity:0.9
Evaporation Rate & Reference:>1 (BU AC=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK AMBER, SOFT WAXY SOLID, PETROLEUM OIL ODOR.
Percent Volatiles by Volume:<0.5

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZING AGENTS.
Stability Condition to Avoid:NOT SPECIFIED BY MFG. HOWEVER AVOID
SOURCES OF IGNITIONS.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF SULFUR, MISC HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH STATE LOCAL AND
FEDERAL REGULATIONS. MATERIALS MAY BECOME A HAZARDOUS WASTE THROUGH
USE. IF PERMITTED, INCINERATION MAY BE PRACTICED. CONSIDER
RECYCLING SOLVENT. EPA HAZ WASTE # NOT APPLICABLE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.